S. D. Wert, Bard, J. F., and H., A., “deSilva and T,” A. Feo (1991). A Simulation Analysis of Semi-Automated Mail Processing Facilities. Journal of the Operational Research Society, vol. 42, pp. 1071–1086, 1991.
An expanded liquid molecular thermodynamic model is developed to predict the solubilities of pure solids in a liquid expanded with a gaseous antisolvent. Experimental data are presented for systems containing naphthalene, phenanthrene, and a mixture of both in toluene expanded with a gas antisolvent, CO2. The pressure range is 1 to 64 bar and the temperature is 25-degrees-C. The data are predicted accurately with regular solution theory up to moderate pressures, but not at the higher pressures where the liquid phase is nearly pure CO2. In contrast, the new expanded liquid equation of state model describes the wide range of behavior from the nearly ideal liquid solution at ambient pressure to the highly nonideal compressible fluid at elevated pressures. As a result, it predicts solubilities accurately over three orders of magnitude by using only binary interaction parameters. The implications of the phase behavior on fractional crystallization with a gas antisolvent are discussed.
The distribution coefficients of the solutes (toluene, naphthalene, and phenanthrene) are reported at infinite dilution between silicone rubber and supercritical-fluid carbon dioxide. A new technique is described in which a thin film of polymer is coated and cross-linked onto silica, and the distribution coefficient is measured rapidly by elution supercritical-fluid chromatography. Because CO2 significantly enhances the solute’s volatility and its diffusion coefficient in the polymer, it is possible to study solute-polymer interactions at room temperature for nonvolatile compounds which would be difficult to study by conventional techniques such as gas chromatography. These infinite dilution data are used to determine solute-polymer interaction parameters to calculate phase diagrams over a wide concentration range. The residual, combinatorial, and cross-link contributions to the solute activity coefficient in the polymer are discussed as a function of concentration. In addition, pronounced pressure and temperature effects are described in terms of experimentally measured solute partial molar volumes (to - 14 L/mol) and partial molar enthalpies (to - 850 kJ/mol) in the fluid phase.
The phase behavior of bis(2-ethylhexyl) sodium sulfosuccinate (AOT)-alkane-brine systems is described over a wide range of pressure, temperature, and salinity for alkanes from ethane to dodecane. The partitioning of AOT between the oil, middle, and brine phases is reported for propane in order to determine the natural curvature. This is important for understanding separation processes with water-in-oil microemulsions. For the lighter, more compressible alkanes, the pressure effect on the hydrophilicity of the surfactant is much larger and in the opposite direction as for the heavier, less compressible ones. In propane at constant temperature and salinity, water-in-oil (w/o) microemulsions have been converted to middle phase microemulsions and then to oil-in-water (o/w) microemulsions by decreasing the pressure. These phase inversions are described in terms of the immiscibilities in the binary systems, and the molecular interactions at the surfactant interface. Although temperature and salinity are used commonly to manipulate interactions primarily on the water side of the interface, these results show it is possible to control interactions on the oil side by adjusting the pressure. The well-established trends in the phase behavior and size of microemulsion drops for dodecane through hexane are not observed for the lighter alkanes. For butane through ethane, a new unusual behavior is identified and attributed to a significant decrease in the strength of the attractive interactions between the surfactant tails and the alkane.
A variety of types of thermodynamic properties have been determined at infinite dilution by supercritical fluid chromatography. A key challenge is to identify clearly the retention mechanism. An experimental technique is presented for the measurement of retention due to absorption into a bulk C-18 liquid (stationary) phase, independently of the adsorption on the support. The important effect of the swelling of the liquid phase by the fluid phase is included. Distribution coefficients are presented for naphthalene and phenanthrene between CO2 and the C-18 liquid phase, and used to determine Henry’s constants in the liquid phase and solute partial molar volumes and enthalpies in the fluid phase. In the highly compressible region of CO2 at 35-degrees-C, solute partial molar enthalpies have been found to reach negative values of hundreds of kJ/mol, indicating strongly exothermic solute-solvent clustering.
The Norrish Type I photofragmentation of two dibenzylic ketones (1,3-diphenyl-2-propanone and 1-(4-methylphenyl)-3-phenyl-2-propanone) in supercritical ethane and carbon dioxide proceeds without evidence for cage recombination of the photogenerated radical pair. A statistical mixture of the bibenzyls formed by random coupling of benzyl and p-xylyl radicals was observed and the first order rate constant for the depletion of the reactant was independent of pressure. These results indicate that solvent cage effects are not operative in these low viscosity supercritical fluids even in the near critical region where solute-solvent clustering is presumably maximal.
The azo-hydrazone tautomeric equilibrium of 4-(phenylazo)-1-naphthol is compared in various liquid and supercritical fluid solvents. The less polar azo tautomer is dominant in the dilute gas phase, compressed ethane, and liquid alkanes. In liquid and supercritical CO2, the equilibrium shifts toward the more polar hydrazone, to yield similar amounts of the two tautomers. This shift is attributed to the Lewis acidity and large quadrupole moment of CO2. The dominance of the hydrazone tautomer in fluoroform (> 90%) can be attributed to that solvent’s large dipole moment and ability to act as a strong electron acceptor (hydrogen bond donor). Since acid-base interactions are prevalent at the lowest pressure studied (1000 psia), changes in the equilibrium constant as a function of pressure have been assigned primarily to increases in the nonspecific polar interactions. The large differences in the polarities, acidities, and basicities of these fluids, despite their similar polarizabilities per volume, are of interest for manipulating chemical processes and for practical applications of supercritical fluid science and technology.